The table below shows the periodic maintenance schedule of the new Suzuki Jimny (since 2018) for all countries except Europe and Israel (for Israel and European countries, see here).
This interval should be judged by odometer reading or months, whichever comes first.
“R” – Replace or change;
“I” – Inspect, clean, adjust, lubricate or replace as necessary.
Beyond 180000 km (108000 miles), perform the same services at the same intervals shown in the chart.
If this table does not fit on the phone screen, you can see it as an image here (will open in a new tab).
Interval | km (x1000) miles (x1000) months | 15 9 12 | 30 18 24 | 45 27 36 | 60 36 48 | 75 45 60 | 90 54 72 | 105 63 84 | 120 72 96 | 135 81 108 | 150 90 120 | 165 99 132 | 180 108 144 |
---|---|---|---|---|---|---|---|---|---|---|---|---|---|
Engine accessory drive belt | I | R | I | R | |||||||||
Valve clearance | I | I | I | I | I | I | |||||||
Engine oil and engine oil filter | R | R | R | R | R | R | R | R | R | R | R | R | |
Engine coolant (SUZUKI LLC: Super (Blue)) | First time - replace at 150000 km (90000 miles) or 96 months. Further - replace every 75000 km (45000 miles) or 48 months. | ||||||||||||
Engine coolant (SUZUKI LLC: Standard (Green) and other) | R | R | R | R | |||||||||
Exhaust system (except catalyst) | I | I | I | I | I | I | |||||||
Spark plugs (When unleaded fuel is used Iridium plug) | Replace every 105000 km (63000 miles) or 84 months. | ||||||||||||
Spark plugs (When unleaded fuel is used Nickel plug) | R | R | R | R | |||||||||
Spark plugs (When leaded fuel is used, Iridium plug) | R | R | R | R | R | R | |||||||
Air cleaner filter element (Paved-road) | I | I | R | I | I | R | I | I | R | I | I | R | |
Air cleaner filter element (Dusty condition) | Inspect every 2500 km (1500 miles); Replace every 30000 km (18000 miles) or 24 months | ||||||||||||
Fuel lines | I | I | I | I | I | I | |||||||
Fuel filter | Replace every 105000 km (63000 miles); For Brazil models: replace every 45000 km (27000 miles) or 36 months | ||||||||||||
Fuel tank | I | I | I | I | |||||||||
PCV valve | Inspect every 80000 km (50000 miles) or 48 monts; For Brazil models: inspect every 90000 km (54000 miles) or 72 months | ||||||||||||
Fuel evaporative emission control system | I | I | |||||||||||
Brake discs and pads (front) | I | I | I | I | I | I | I | I | I | I | I | I | |
Brake drums and shoes (rear) | I | I | I | I | I | I | |||||||
Brake hoses and pipes | I | I | I | I | I | I | |||||||
Brake pedal | I | I | I | I | I | I | I | I | I | I | I | I | |
Brake fluid | I | R | I | R | I | R | I | R | I | R | I | R | |
Brake lever and cable | I | ||||||||||||
Clutch pedal | I | I | I | I | I | I | I | I | I | I | I | I | |
Clutch fluid | I | R | I | R | I | R | I | R | I | R | I | R | |
Tyres / Wheels | I | I | I | I | I | I | I | I | I | I | I | I | |
Wheel bearings | I | I | I | I | I | I | |||||||
Propeller shafts | I | I | I | I | |||||||||
Suspension system | I | I | I | I | I | I | |||||||
Steering system | I | I | I | I | I | I | |||||||
Manual transmission oil (Genuine “SUZUKI GEAR OIL 75W") | Inspect every 30000 km (18000 miles) or 24 monts; | ||||||||||||
Manual transmission oil (Other than “SUZUKI GEAR OIL 75W") | I | R | R | R | R | ||||||||
Automatic transmission oil (Fluid level) | I | I | I | I | I | I | |||||||
Automatic transmission oil (Fluid change) | Replace every 165000 km (99000 miles). | ||||||||||||
Automatic transmission oil (Fluid hose) | I | I | I | ||||||||||
Transfer oil (Genuine “SUZUKI GEAR OIL 75W") | Inspect every 30000 km (18000 miles) or 24 monts; | ||||||||||||
Transfer oil (Other than “SUZUKI GEAR OIL 75W") | I | R | R | R | R | ||||||||
Differential oil (Genuine “SUZUKI SUPER GEAR OIL 75W-35 SYNTHETIC") | R | I | I | I | I | I | |||||||
All latches, hinges and locks | I | I | I | I | I | I | |||||||
Air conditioner filter element | I | R | I | R | I | R | I | R |